How to replace rear wheel bearing / rear hub bearing on ALFA ROMEO 159 1 (939) [TUTORIAL AUTODOC]
How to replace rear wheel bearing / rear hub bearing on ALFA ROMEO 159 1 (939) [TUTORIAL AUTODOC]


Required tools:
Wire brush
WD-40 spray
Copper grease
Drive socket # E14 Drive socket # 19
Drive socket # 21
Drive socket # 36 HEX bit No.H4.
HEX bit No.H7.
Wheel impact socket #17
Ratchet wrench Torque wrench
Ball joint puller
Flat Screwdriver Tap wrench
Crow bar
Rubber mallet Hydraulic transmission jack
Wheel chock 1. Raise the rear of the car and secure on supports. 2. Unscrew the wheel bolts.
Use wheel impact socket #17. AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts. 3. Clean the brake caliper fasteners.
Use a wire brush.
Use a brake cleaner. AUTODOC recommends:
After applying the spray, wait a few minutes. 4. Unscrew the brake caliper fastening.
Use a combination spanner #13.
Use a combination spanner #15. 5. Remove the brake caliper.
Use a crowbar. AUTODOC recommends:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.
Make sure that the brake caliper is not hanging on the brake hose. Don’t press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. 6. Remove the brake pads.
Use a crowbar.
Remove the brake pads retaining clips. 7. Remove the brake pads retaining clips. 8. Clean the brake caliper bracket fasteners. Use a wire brush.
Use WD-40 spray. 9. Unscrew the caliper bracket fastening.
Use a drive socket #E12.
Use a ratchet wrench. 10. Remove the caliper bracket 11. Clean the brake disc fasteners.
Use a wire brush.
Use WD-40 spray. 12. Unscrew the brake disc fastening
Use HEX No.H5.
Use a ratchet wrench. 13. Remove the brake disc. 14. Clean the wheel hub fastener.
Use a wire brush.
Use WD-40 spray. 15. Unscrew the wheel hub axle nut.
Use a drive socket #E14.
Use a ratchet wrench. 16. Remove the fastening bolts. 17. Remove the hub and the bearing together, since they are a sealed unit. Use a crowbar.
Use a hammer. 18. Clean the hub bearing mounting seat.
Use a wire brush.
Use all-purpose cleaning spray. 19. Treat the contacting surface.
Use copper grease. 20. Install the new wheel hub with a bearing. 21. Install the fastening bolts. 22. Tighten the hub.
Use a drive socket #E14. Use a torque wrench.
Tighten it to 80 Nm torque. 23. Treat the hub where it contacts the brake disk.
Use copper grease. 24. Install the brake disc. 25. Tighten the brake disc fastening.
Use HEX No.H5.
Use a torque wrench.
Tighten it to 9 Nm torque. 26. Install the brake caliper bracket. 27. Tighten the brake caliper bracket.
Use a drive socket #E12. Use a torque wrench.
Tighten it to 75 Nm torque. 28. Install the brake pads retaining clips. 29. Install the brake pads. 30. Install the brake caliper and fix it.
Use a combination spanner #13.
Use a combination spanner #15. Use a drive socket #13.
Use a torque wrench.
Tighten it to 35 Nm torque. 31. Treat the surface where the brake disc contacts the wheel rim.
Use copper grease. 32. Clean the brake disk surface.Use a brake cleaner. AUTODOC recommends:
After applying the spray, wait a few minutes. 33. Screw in the wheel bolts.
Use wheel impact socket #17. AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts. 34. Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench.
Tighten it to 120 Nm torque.

3 thoughts on “How to replace rear wheel bearing / rear hub bearing on ALFA ROMEO 159 1 (939) [TUTORIAL AUTODOC]”

  1. Master Jedi says:

    First

  2. Алексей A. says:

    Good 👍👍👍

  3. autodoc.co.uk says:

    Have a look at other videos on our channel:

    🔸 ALFA ROMEO 159 car repair tutorial — https://www.youtube.com/playlist?list=PLWep5LzT0sxldURmVSOWcmRWqr8lp6kxM

    🔸 How to replace front anti roll bar link on ALFA ROMEO 159 1 (939) —
    https://youtu.be/P7jCoEKbFk0

    🔸 How to replace a front shock strut on ALFA ROMEO 159 1 (939) —
    https://youtu.be/czaXgAAgGHU

    🔸 How to replace wipers blades / window wipers ALFA ROMEO 159 1 (939) —
    https://youtu.be/xl9Tqwo1rbM

    🔸 How to replace air filter on ALFA ROMEO 159 1 (939) — https://youtu.be/hy3A9s3zWJA

Leave a Reply

Your email address will not be published. Required fields are marked *